TRACTOR, WHEELED, DED LOADER BACKHOE: WITH HYDRAULIC IMPACT TOOL AND WITH HYDRAULIC EARTH AND WITH HYDRAULIC EARTH

LO 5-2420-222-12

LUBRICATION ORDER

3 April 1992

(Supersedes LO 5-2420-222-12,

dated 1 September 1987)

TRACTOR, WHEELED, DED LOADER BACKHOE:

WITH HYDRAULIC IMPACT TOOL

AND WITH HYDRAULIC EARTH

AUGER ATTACHMENT

JOHN DEERE MODEL JD410(CCE)

WITH BUCKET, IMPACTOR,

AND EARTH DRILL

NSN 2420-00-567-0135

Reference: TM 6-2420-222-10, TM 5-2420-222-20, and C9100-IL.

and gloves, and use only in a well-ventilated

Intervals (on-condition or hard time) and the related

area. Avoid contact with skin, eyes, and

man-hour times are based on normal operation. The

clothes, and DO NOT breathe vapors. DO NOT

man-hour time specified is the time you need to do all

use near open flame or excessive heat. The

the services prescribed for a particular interval.

solvent's flash point is 100"F-138F

On-condition (OC) oil sample intervals shall be

(38C59C). If you become dizzy while using

applied unless changed by the Army Oil Analysis

cleaning solvent, immediately get fresh air and

Program (AOAP) laboratory. Change the hard time

medical help. If solvent contacts eyes,

interval if your lubricants are contaminated or if you

Immediately wash your eyes and get medical

are operating the equipment under adverse

operating conditions, including longer-than-usual

aid.

operating hours. me hard time interval may be

Clean fittings before lubricating. Clean parts with dry

extended during periods of low activity. If extended,

cleaning solvent P-D-680, Type II or equivalent. Dry

adequate preservation precautions must be taken.

before lubricating.

Hard time intervals will be applied in the event AOAP

laboratory support is not available.

Broken arrow shafts (- - -) indicate lubrication

points on both sides of the equipment.

WARNING

me lowest level of maintenance authorized to

lubricate a point is indicated by one of the following:

Dry cleaning solvent, P-D-680, is toxic and

Maintenance.

flammable. Always wear protective goggles

REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS

You can help improve this manual. If you find any mistakes or if you know of a way to improve the

procedures, please let us know. Mail your letter or DA Form 2028 (Recommended Changes to

Publications and Blank Forms) direct to: Commander, U.S. Army Tank-Automotive Command, ATTN:

AMSTA-MB, Warren, Ml 48397-5000. A reply will be furnished to you.

Approved for public release; distribution is unlimited.

TA509994

CARD 1 OF 7

LO 5-2420-222-12